空調壓縮機頻繁啟動

在空調壓縮機啟動過程中，通常存在降壓啟動回路，但啟動電流仍可超過額(e)定電流的數倍，空調壓縮機電機啟動溫度上升非常快。如果空調溫度設置不當，制冷溫度過低，制熱溫度過高，會造成空調壓縮機頻繁開、關，會縮短空調壓縮機的使用壽命。

2. 空調壓縮機電壓不穩定

電源電壓質量差，如電壓過高或過低，都會對空調壓縮機電機產生負面影響，特別是在超出空調壓縮機額(e)定電壓范圍使用時。最不恰當的使用，會使空調壓縮機電機長期運行后處于低效過熱狀態，造成絕緣不良，燒毀電氣繞組。此外，三相電壓或電流不平衡還會造成電機損耗增加(鐵、銅損耗)，空調壓縮機電機線圈溫度過高，過熱器保護不當，空調壓縮機電機絕緣燒毀，造成空調電機線圈短路燒毀。

3.壓縮機燒壞后，制冷系統沒有徹底清洗

對于以前出現過壓縮機燒損故障的空調制冷系統，有必要對制冷系統進行徹底清洗。當空調壓縮機電機被燒毀時，將產生強酸并留在系統中。如果處理不徹底，新空調壓縮機電機運行后，殘留的酸性物質會腐蝕空調壓縮機電機的保溫層，造成新空調壓縮機燒壞。

4. 銅管系統清潔度不夠

它含有水分，也會造成空調壓縮機電機絕緣不良;系統中水、制冷劑、冷凍油的循環，通過溫度和溫度的變化，會產生酸性物質，會損壞電機的絕緣層。久而久之，空調壓縮機電機就會燒壞。